广西顶博发电机组制造

13667715899

添加微信好友了解产品w13667715899

当前位置:首页 > 技术支持

又到暴雨潮湿季节了,广西顶博发电机组制造进水该怎么办?

2021-07-31
来源: 原创
10631
当梅雨季或热带气旋季来异地,有或许受洪涝洪涝、特大暴雨等自然是洪涝的干扰,因静音生产发交流接触器组计算机机房似的是在低下室还是1楼便捷被水淹,如生产发交流接触器组保存预防疏于还是其余主要原因水有或许从烟管進入起动因缸体。当静音生产发交流接触器组漏液时,要是在在运转请尽快暂停服务,并采用重要的的措施,切断外主机电源及汽车蓄电池板接驳线,此外查验各类位置的漏液前提。


When the rainy season or typhoon season comes, it may be affected by natural disasters such as flood and rainstorm. Because the diesel generator set room is generally in the basement or the first floor, it is easy to be flooded. If the generator set is poorly kept and protected or for other reasons, water may enter the engine cylinder from the smoke pipe. When water enters the diesel generator set, if it is running, please shut down immediately, take necessary measures, disconnect the external power supply and battery connection line, and check the water inflow at all parts at the same time.


广西顶博发电机组制造机房


检查广西顶博发电机组制造进水常见问题

1、常规检查排气管滤油器(排烟系统管最低标准处或排气消声器器)的泄水支座是不是也有冰排下来。Check the exhaust pipe to see if there is water discharged from the drainage component.


2、捡查热空气空气净水器滤芯器塑料外壳是否需要需要有淹水,净水器滤芯是否需要需要被水浸渍。Check whether there is water in the air filter housing and whether the filter element is immersed in water.


3、排查电站机护壳下端是否有有内的积水。Check whether there is water accumulated at the bottom of the generator casing.


4、檢查排热器、空调风扇、梅花联轴器等转回元器件有没有阻塞。Check radiator, fan, coupling for blockage.


5、第三方会不可挥发油、汽柴油或水的渗漏。Whether there is leakage of organic oil, fuel or water from the outside.


6、拆换连杆室盖,关注是否需要有泡水。排查并网发变频电动机绕阻绝缘带/严重污染情況。Remove the rocker chamber cover and observe whether there is water ingress. Check the insulation and ontamination of the generator windings.


7、测量保持高压线路和输送电路设计的电绝缘。测量保持盖板功能、各电子仪表、告警装置设备、启动的电开关。Check the insulation between the control circuit and the output circuit. Check the control panel module, each instrument, alarm device and start switch.


关注:任何时候没法让水侵蚀打着机的燃烧物室!Note: Never let water enter the combustion chamber of the engine!


手表进水外理技术柴油机发电量飞机机组接触不良后的加工方法:Treatment  after water enter the generator:


当区分柴油车密度电站制冷空气能热泵机组打火机的然烧室不手表进水,隔热符合必须必须时,可开启柴油车密度电站制冷空气能热泵机组。在开启时要小心接下来问题:When confirm there is no water in the combustion chamber  and the insulation meets the requirements,can start the generator. Pay attention to the following issues when starting:


1、在开始奋勇前进行大多数全面检查,比如排放物汽柴油箱渗水。电气公司软件系统计划经济体制上电,留意是有问题。Do all inspections before starting, including draining water in the fuel tank. The electrical system is gradually powered on, and observe whether there is any abnormality.


2、反复开启打着机的期限允许高达三十秒钟。若打着机不可自燃,则排查汽油管道阀门及电力设备电路,二两min后在此开启。Start the engine continuously shall not exceed 30 seconds. If the engine cannot catch fire, check the fuel line and electrical circuit, and start again after one or two minutes.


3、审核打着机音乐声会不有失常,会不有怪味。审核电气公司设备的提示、液晶板提示屏会不断屏或许提示不清。


Check whether the engine sound is abnormal and whether there is a peculiar smell. Check whether the display of the electrical instrument and the LCD screen are broken or unclear.


4、密不可分分析汽车齿轮油工作压力和水的温湿度,如果油压机或的温湿度不相合乎技術标准规范,应闭合打火机。停用后,查以此汽车齿轮油平米。Closely observe the oil pressure and water temperature. If the oil pressure or temperature does not meet the technical specifications, the engine should be shut down. After stopping, check the oil level.


当评断汽车发动因有可能进水量、风能主轴电机的隔热不一致合想要时,不应随意返修,应去寻找风能主轴电机的组产品的工程专业工艺的人员的关心。When it is judged that water may enter the engine and the insulation of the generator does not meet the requirements, do not repair it without authorization, and seek the help of professional technicians from the generator manufacturer.


特大暴雨/朝湿生态环境,静音发电厂电机实用需要注意关键环节Key points for unit operation in rainstorm / humid environment


1、放上情况符合要求1. Placement environment requirements(1)室内防止便用的汽轮发电机组,需做到位防潮布的措施,增加防潮布棚、隔音箱等;


Rainproof measures shall be taken for units placed outdoors, and rainproof sheds, static speakers, etc. shall be equipped;


(2)空调机组底壳须有牢靠的确保跨接,对都要 有弱酸性点立即跨接的风能发直流无刷电机,则都要由技术专业的人员开展弱酸性跨接;The shell of the unit must be reliably grounded. For generators requiring direct neutral grounding, the neutral grounding must be carried out by professionals;


(3)打雷发多中北部选择器机,请设置防雷平衡装置。If machines are used in lightning prone areas, please configure lightning protection devices.


(4)请尽量不要将热泵机组置于于地形较低,地基基础不牢(沙子地面的)简易 淹水的点;Please do not place the unit in a place with low terrain, weak foundation (soil ground) and easy to accumulate water;


(5)摆放在在地面室的使用的系统,需准备好地面室雨排、防渗本职工作。For machines placed in the basement, drainage and moisture-proof work in the basement shall be done well.
强烈推荐原创文章
柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家